Hey lads in relation to a previous post re intercooler — S2forum - Audi S2 Owners

Hey lads in relation to a previous post re intercooler.

My turbo i used was a owens GTX3576 Tial .82 i actually ordered this for my S3 8P so owens built it with the 2inch compressor housing so the housing itself is actually smaller than the 2.5inch verson so im told they struggle past the 550hp and from here to 516awhp it brought my temps right up so really it probably wasnt my intercooler more the case it choked and was past its efficiency blowing a shitload off hot air.

So im thinking Gen 2 GTX3576 or Gen 2 GTX3582.

Anyone have any input ?

%d comments

    Hey guys i was wondering how i can re use the pressure plate is still in good... — S2forum - Audi S2 Owners

    Hey guys i was wondering how i can re use the pressure plate is still in good condition? Reason im asking this is because im swapping out my clutch plate for a springless sintermetallic version. It was An expensive Sachs clutch and the Padding isn't that worn out. Should i invest in het again a high performante clutch or can i just swap out the clutch plate with a springless one? Reason im doing is because im going up in horsepower someone said that the springs could break under high load with high hp levels.

    %d comments

      Could anybody help me — S2forum - Audi S2 Owners

      Could anybody help me?

      I have to know the pinout of zeitronix WBO cable. A zeitronix has been installed in a B5 RS4 but the car will get a VEMS for datalogging and want to use the zeitronix wbo cable. I can't put out the WBO cable to check the color/pinout of WBO connector because i should dissasemble the half of engine bay.

      Thanks!

      %d comments

        Photos from Rob Griffiths's post — S2forum - Audi S2 Owners

        For sale. A6 C4 2.5 TDI quattro avant. 238.000 miles. Extensive service history.

        Ming blue pearl. Black leather. Tilt/slide electric sun roof. Sport three spoke steering wheel. Wietec shockers. S6 springs. S6 rear brakes. S6 boot panel. S6 wheels. Westfalia removable tow bar. Bosio injector nozzles. Diesel pump seals replaced. Cruise control. Recently replaced and painted front wings bonnet and bumper. Repaired and protected fuel tank. HID headlight bulbs.

        170 bhp chips. Large history file. Dinitrol two layer corrosion coatings. Propshaft centre bearing replaced.

        Radiator replaced. Genuine cam belt/tensioner 230k 2014.

        12 months mot and inspection service.

        £4000.00

        %d comments

          Photos from Ev Geniy's post — S2forum - Audi S2 Owners

          Hi guys,

          don't know if people have come across this problem but will give it a shot...

          I'm rebuilding my 93'AAN head and I have a problem fitting the valve spring seat washer. I have bought new valve guides to fit but they have a "collar" that prevents the washer to sit as intended.

          I've looked at AAN workshop but it doesn't mention anything about the washer.

          Any ideas what people do to fit the washer are greatly appreciated.

          I attach some pictures for clarity. part number for the washer is 034109629

          cheers Eugene

          %d comments

            Photos from Josch Light's post — S2forum - Audi S2 Owners

            Hallo,

            ich habe mir günstig einen S2 Avant gekauft.

            Dieser benötigt aber noch etwas Zuwendung. So läuft der Motor noch unrund. Denkt ihr es liegt an den Zündspulen? Die sind wohl ein bekanntes Problem beim ABY.

            Außerdem funktionieren alle Fensterheber nicht und wenn ich den Schiebedachschalter drücke kommt nur ein Surren. Das Relais wurde gegen ein gebrauchtes getauscht, aber brachte keine Veränderung.

            Ansonsten benötigt er optisch noch Pflege, aber das wird erledigt wenn es wärmer wird.

            Hello,

            I bought a S2 Avant.

            But this still needs some attention. Thus, the engine has uneven idle. Do you think it's due to the ignition coils? These are a known problem with the ABY.

            Also, all electrical windows do not work and when I push the sunroof switch comes just a whirring. The relay was exchanged for a used one, but brought no change.

            Otherwise, it still needs optical care, but that is done when it gets warmer.

            %d comments

              Car, audi s2 3b — S2forum - Audi S2 Owners

              voy a vender mi Audi S2 el coche se inundó. La carrocería está bien, SIN OXIDO, SE SECÓ MUY RÁPIDO, el motor no está oxidado. El interior se tuvo que quitar. Regalo centralita AAN, árboles de levas 7, a colector Wagner tuning T3 y algunas cosas, como juego de juntas para culata victor reinz. Es un 3B gris metalizado está parcialmente desmontado. El cableado debería estar bien, no tenia bateria, no se ha cortocircuitado. las centralitas se secaron, la moqueta y aislante se quitaron, arrancados para evitar corrosion, los asientos y el cuero no tienen moho. Techo abatible. 8500€. No despiezo.

              %d comments

                Moin Männers — S2forum - Audi S2 Owners

                Moin Männers,

                ich brauche mal einen S2 Experten da ich mit meinen Latein langsam am Ende bin. Es handelt sich um einen S2 Avant aby mit

                Tom Schmalz Chip auf 280ps.

                Hab vor ca 1 Jahr einen überholten Motor eingebaut und seid her das Problem das er im Notlauf ist.

                Baut maximal 0,5Bar Ladedruck auf und der Fehlerspeicher gibt nicht wirklich was her.

                Folgendes wurde schon kontrolliert und ausgetauscht.

                - neuer Lader bei Motorwechsel

                - SUV und N75 neu

                - diverse Ladedruck und unterdruck Schläuche erneuert

                - Lmm überprüft und durch RS2 Lmm ersetzt

                - Zündspulen ggn RS3 Einzelfunken ersetzt

                - Zündkerzen und Kraftstofffilter neu

                - überholtes Wastegate mit neuer Membran

                - Lambdasonde neu

                Ladedrucksystem ist komplett dicht, er baut den Ladedruck sauber auf und wenn man das N75 blind legt baut er auch zwischen 3 und 4000 Umdrehungen vollen Ladedruck auf.

                So läuft der Motor sauber und ohne stottern.

                Der vorherige Motor lief sauber und hatte volle Leistung bis zum Motorschaden.

                Was noch zu erwähnen wäre ist das er ein Fidanza Aluschwungrad bekommen hat beim Motorwechsel.

                Ich hoffe das mir irgendjemand noch helfen kann bin leider ein wenig am Verzweifeln an meinem Liebling.

                %d comments

                  Photos from Mark Sanderson's post — S2forum - Audi S2 Owners

                  For sale, Audi s2 ,kingfisher blue, 4 previous owners service history and stacks of receipts, all old mots, 140k , full black leather carbon inserts, carbon sill trims,carbon engine cover ,uprated coil pack, rs2 turbo, large brake conversion, ecu ,updated oil cooler, new disks and pads, koni suspension, milltek 3" full exhaust system from turbo to back, poly bushed , full belt overhaul inc water pump and timing kit ,Audi A8 18" alloys done black chrome with new uniroyal tyres all round genuine interest offers around 11k please pm thanks.......DEPOSIT TAKEN

                  %d comments

                    So I came to start my car tonight and I find my rear fog light button was... — S2forum - Audi S2 Owners

                    So I came to start my car tonight and I find my rear fog light button was illuminated in red. I tried turning the car over but the battery was almost pretty much dead..Now I've jump started the car and all the indicators front and back as well as interior are on and won't go off.

                    Can anybody give me any pointers? Am gonna start by checking my hazard lights button/relay as well as for any shorted bulbs to see what's going on. Any help is appreciated!

                    %d comments

                      Photos from Guy McCallum's post — S2forum - Audi S2 Owners

                      Morning all!!!

                      Question about compatibility between instrument clusters......

                      I've got a 2.0e b4 Audi 80 running a VDO (manufacturer) 120mph cluster and the odo and trip don't work. I've changed a wee cog but hasn't made a difference, so now I'm looking to see if there is a problem with the circuit board.

                      In the mean time I'm trying to establish what other clusters could be used for compatible parts, i.e. The circuit board that puts power to the speedo and there for the odo and trip. I should say my speedo is working just not the odo and trip.

                      This is the circuit board and a couple of other pics of the cluster...

                      %d comments

                        Bräuchte eure Hilfe Ich weiß ist blöd ohne Bilder oder genaue Daten aber ich... — S2forum - Audi S2 Owners

                        Bräuchte eure Hilfe. Ich weiß ist blöd ohne Bilder oder genaue Daten, aber ich will trotzdem mal anfragen.

                        Mir wurde ein S2 Avant 3b aus Erstbesitz angeboten. Hat mittlerweile über 300tKm und sieht optisch runtergekommen aus. Technisch ist aber alles gut. Ist eben als typischer Dailydriver genutzt worden.

                        Was wäre eine ganz grobe Preiseinschätzung: ich denke € 6 - 10.000 ist der momentane Marktpreis, oder?

                        %d comments

                          Photos from Jules Thompson-ceney's post — S2forum - Audi S2 Owners

                          Hi guys, have fitted my new headlights but they just don't seem to sit right to me, I know there's two fixings at the top, but am unsure of where the others fix to?

                          The thin strip under the headlights doesn't marry up to well either, I can't find too much info online about the correct fixtures and fittings for them, so any help or photos would be great

                          %d comments

                            HI everyone — S2forum - Audi S2 Owners

                            HI everyone,

                            I would like to change my suspension in CQ 7A '89.

                            Could you recommend some suspension for Rally starts? I don't want to have lowrider :) but some suspension which will be little bit higher than h&r or another sets at all.

                            %d comments

                              Photos from József Balog's post — S2forum - Audi S2 Owners

                              WTS, Wants To Sell :)

                              '94 Audi S2 Coupé with ABY engine in good overall condition. Bought by me in 2004 with 227 tkm and used as a hobby car, on weekends only. Now it is my 3rd car..The car was fully restored mechanically in 2006-2007, including changing the car body to one of an '95 S2 Coupé. Since then I almost did not use the car, the actual mileage is 243 tkm. The car is fully roadworthy, however due to the long stillstand some minor technical problems occurred, which, of course will be eliminated before selling the car. The car is in original condition except for the ignition coils originating from an S8 (I will check the coil numbers tomorrow), the modded ECU (about 260 BHP) and the front bumper (RS2 replica). The front brakes have been upgraded to 323 mm Porsche brakes. Painting is not perfect, needs some work, poishing or repaint depending on the demands of the buyer. The rear window wiper is defect, it's most probably the switch. Air conditioning was fully operational on the last use, however, it might need a refill. Car stands on summer tyres.

                              13500€

                              %d comments

                                Hi all — S2forum - Audi S2 Owners

                                Hi all.

                                1995 RS2

                                All of a sudden i have just the center vents working in my Automatic Air Condition

                                Not footwell nor windscreen.

                                I know that the servo for feet and windscreen it's one

                                But if i push the buttons i don't hear the dedicated servo working

                                Also the one for the dash vents it's silent.

                                I know that in order to direct air to the feet or the wind screen firstly the center flap should close.

                                VAG says that both servo motors are "no voltage"

                                Temperature flap works ok.

                                Already tried to change the ECU with another one in perfect order but no joy...

                                Is it possible that both servomotors are fubar?

                                Anyone so kind to source the wiring of the Auto A/C?

                                Any suggestions?

                                Thanks in advance

                                Stefano

                                %d comments

                                  Morning guys have got an issue with my s2 aby it keeps cutting out when sat in... — S2forum - Audi S2 Owners

                                  Morning guys, have got an issue with my s2 aby, it keeps cutting out when sat in traffic, initially I thought it was the idle control valve, so I bought one and changed it, but it's made it worse if anything, it cuts out when stationary, it's only started since I removed the beer can air filter shield, any help would be epic before I burn it!!

                                  %d comments

                                    Last Dub — S2forum - Audi S2 Owners

                                    Admin pls help us promote our group in urs n u can do likewise in ours. Guys come join our fast growing active group where we have some beautiful VAG MACHINES. We have TIE UPS WITH INSURANCE, TUNING, PERFORMANCE PARTS COMPANIES etc. Take advantage. Thanks..

                                    %d comments